This must me done while the car is cool, any attempt to do this while the car is hot will result in minor or major burns. Do this at your own risk.
Drain radiator by unsrewing the top cap and locating the drain cock in the bottom left hand corner of the radiator, disconnect the radiator hoses from the top and the bottom of the radiator. Get 2 14mm bolts(for A/T) and disconnect the two lines at the bottom of the radiator that goes to the A/T and screw the 14mm bolts into the hole so it doesnt leak any fluid. Unplug the radiator fans and unbolt the radiator support brakets that holds the radiator in place. Slowly pull the radiator up and out of the way making sure there is nothing left connected to it to hold it down.
Now that the radiator is out you wanna lay it on the floor and start unbolting the radiator fans and swapping them onto the new radiator.
Once done you want to install the new radiator in reverse order when you took it out.
Have like 2 gallons of Antifreeze, pour it in the radiator till it reaches a certail level, you will know when. Then start the car, and let run with the pressure cap off, when the engine reaches normal operating temp the fans will come on (for faster results you could rev the engine to make the fans come on) When they do, add more antifreeze it will go down slowly and bubbly cuz air is coming out, repeat this untill you have filled the radiator and it appears that it cannot take anymore. Replace the pressure cap and get the 12 or 14 i believe and look for the bleeder valve, should be a lil nut in the thermostat housing or some effect. Feel the top and bottom radiator hoses for heat and little by little loosen the bleeder valve till you see all the air and steam start to flow, repeat this process till no more air comes out, only antifreeze(hot). Then tighten the pressure valve and fill your resevoir to the half mark.
Get inside the car and turn on the heat to high and hot. Does heat come out of the vents?
Also check for leaks and check your temp guage, it should be at the right mark. On my G it doesnt even reach the middle mark but others may differ.
I might have missed a few things but when i do small jobs like that it really is a no brainer.
Bookmarks